We consider the manure removal system, which is used in most pig farms being built and reconstructed at present in Ukraine, and it has been discovered that there are major mistakes during the baths construction in the correct geometry and depth, and therefore discusses their rules of operation. If the baths geometry is wrongly executed, for instance, if the slope is made to slant toward the bottom of the tub filler drain pipe, which in itself is unacceptable, or not properly executed in the form of a special pit steps towards the neck drain, and etc., then a number of problems is inherent of its exploitation. The basic requirements for laying fused-pipe is compliance with its slope. The considered equipment must be equipped with pumping stations to pump manure. The pumps for pumping manure: submersible sewage pumps and dry-installed in the mine and long sewage pumps with electric or PTO shaft of a tractor were analyzed. Attention was paid to the designing of modern equipment for the distribution of manure waste into fractions. The classification of manure storage and the basic requirements for their placement and arrangement was carried out, and recommendations are made for the designing of pumping stations, to select pumps for the pumping stations and the design during the modern construction and reconstruction of old pig farms.
Biogas production has a big potential to provide clean energy. To evaluate the future production and maturity of biogas technology the generalized Weng model was proved to be effective, due to it has the minimum error. The simple algorithms to determine its parameters have been proposed. The simulation results for China, USA, and EU have been presented. The quantity and quality analysis for biogas feedstock has been carried out. Energy Return on Energy Invested (EROEI) indicator for different biofuels was considered. According to analysis done biogas from maize residue and chicken manure has high EROEI. Shannon Index was suggested to evaluate the diversity of feedstock supply. Biomass energy cost indicator was grounded to be used for feedstock energy and cost assessment. Biogas utilization pathways have been shown. Biogas boilers and CHP have the highest thermal efﬁciency, but biogas (biomethane) has the highest potential to earn as a petrol substitute. Utilization of biogas upgrading by-product (carbon dioxide) enhances proﬁtability of biogas projects. Methods to assess the optimal pathways have been described.
The aim of this study was to implement ADM1xp model to simulate behavior of anaerobic co-digestion of maize silage and cattle manure. The accuracy of ADM1xp has been assessed against experimental data of anaerobic digestion, performed at OLR = 2.1 gVS dm-3·d-1 and HRT = 45d. Due to the high number of parameters in ADM1xp, it was necessary to develop a customized procedure limiting the range of parameters to be estimated. The best fitting of experimental to simulated data was obtained after verification of 9 among 105 stoichiometric and kinetic parameters. The values of objective function (Jc) ranged between 0.003 (for valerate) and 211 (for biogas production).
This paper presents the results of fractionation of particulate and soluble organic matter in a mixture of maize silage and cattle manure (49:51% volatile solids) that was used as a feedstock for anaerobic digestion. The extended Weender’s analysis was adapted to measure raw protein, raw lipids, fraction of carbohydrates (including starch, cellulose, hemicelluloses) and lignin. The content of individual fractions in composite, Xc (as kg COD kg-1 COD) was: 0.111 proteins, 0.048 lipids, 0.500 carbohydrates and 0.341 inerts. The biodegradability of Xc was 68%. Based on material balance, the carbon concentration in Xc was 0.0326 kmol C kg-1 COD, whereas nitrogen concentration 0.0018 kmol N kg-1 COD. The estimated pH of the feedstock based on acid-base equilibrium corresponded to the actual value (pH 7.14).
One of the methods of sewage sludge disposal, which is based on its fertilizing properties, is its use in nature, e.g. in farming (if all the permissible standards are met). However, the sludge used for soil fertilization might also contain heavy metals, pathogenic microorganisms, thus causing contamination in soil foundation and deterioration of the conditions for development of indigenous organisms. Particular threat is posed by the existence of drug-resistant microorganisms in sewage sludge. This problem has not been researched in detail yet. The authors of the present study aimed to determine qualitative changes in drug-resistant microorganisms in sandy soil fertilized with selected sewage sludge. Sewage sludge after different types of drying process (natural and solar) was added to the degraded sandy soil. The effect of the methods of sewage sludge drying on concentration of drug-resistant microorganisms in soil fertilized with the sludge was analysed. The study demonstrated that sewage sludge dried naturally in drying beds pose threat to soil environment and, potentially, to people and animals which have contact with fertilized soils. In sandy soils fertilized with these types of sewage sludge, pathogenic forms which exhibit resistance to first-line antibiotics can be found.